基于T-S模糊神经网络模型的编码器故障软闭环容错控制方法

摘要
图/表
参考文献(0)
相关文章 (15)

全文: PDF (803 KB) HTML
输出: BibTeX | EndNote (RIS)

摘要

针对舞台吊杆调速系统中速度反馈元件增量式编码器可能产生的丢码、断码等问题,为防止故障影响的传播,结合数据驱动技术提出了一种基于T-S模糊神经网络(T-S FNN)模型的编码器故障检测与软闭环容错控制方法。首先,利用系统正常运行时的历史数据建立系统较为精确的T-S FNN预测模型,并用实际编码器测量值与模型预测值相减获得残差信息；其次,将其残差实时数据通过改进的序贯概率比检验(SPRT)算法进行故障检测,以克服检测延迟确保故障检测的可靠性,当检测出故障时,再用T-S FNN模型的预测输出替代故障编码器的输出,实现软闭环方式下的容错运行；最后,针对编码器丢码、断码等故障,采用上述方法进行了软闭环容错控制的有效性仿真验证。仿真结果表明,该方法能够快速可靠地检测到编码器故障,并用预测的重构信息通过容错切换机制,及时、安全地以软闭环方式实现了对故障编码器的容错控制,提高了舞台吊杆调速系统运行的安全可靠性。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	李炜
	李青朋
	毛海杰
	龚建兴

Abstract：

In order to solve the problem of losing codes and pausing codes in the incremental encoder which conventionally used in the stage speed boom system as speed feedback component and prevent the propagation of fault effect, a fault detection and soft close-loop fault-tolerant control method for encoder faults based on the Takagi-Sugeno Fuzzy Neural Network (T-S FNN) model combined with the data-driven technique was proposed. First, the system of T-S FNN prediction model was established by substracting the system normal operation of historical data, and achieved the residual error information by using measured values of actual encoder and predicted values. Next, encoder fault was detected by using improved Sequential Probability Ratio Test (SPRT) algorithm though the residual error real-time data information, in order to overcome the detection delay and ensure the reliability of fault detection. Then, according to the prediction model output which was used as the output of the encoder failure to accommodate the failure when fault was detected, in order to realize the soft fault-tolerant operation by using close-loop mode. At last, the encoder fault tolerant process for the losing codes and pausing codes was proved by simulation experiment effectively. The simulation results show that the method of this article can detect the encoder fault information rapidly and reliability, and switch from the fault-tolerant mechanism timely and safely by using the reconstruction of the prediction information, in order to realize the soft closed-loop fault-tolerant control of encoder failure and improve the safety and reliability of stage speed boom system operation process.

收稿日期: 2014-06-16 出版日期: 2014-12-31

中图分类号:

TP212.1

基金资助:

国家自然科学基金资助项目;甘肃省自然科学基金资助项目;兰州理工大学校基金资助项目

通讯作者: 李青朋 E-mail: 739412535@qq.com

作者简介: 李炜(1963-),女,陕西西安人,教授,博士生导师,主要研究方向:工业过程先进控制、动态系统的故障诊断与容错控制；李青朋(1987-),男,河南安阳人,硕士研究生,主要研究方向:控制系统的故障诊断与容错控制；毛海杰(1978-）,女,内蒙古赤峰人,讲师,主要研究方向:动态系统的故障诊断与容错控制；龚建兴(1968-),男,甘肃酒泉人,高级工程师,主要研究方向:舞台机械电气控制系统设计。

引用本文:

李炜李青朋毛海杰龚建兴. 基于T-S模糊神经网络模型的编码器故障软闭环容错控制方法[J]. 计算机应用, 2014, 34(12): 3646-3650. LI Wei LI Qingpeng MAO Haijie GONG Jianxing. Method of soft close-loop fault-tolerant control in encoder faults based on the T-S fuzzy neural network model. Journal of Computer Applications, 2014, 34(12): 3646-3650.

链接本文:

http://www.joca.cn/CN/ 或 http://www.joca.cn/CN/Y2014/V34/I12/3646

［1］DU Y, WANG X, WANG S, et al. Auto-detection system of incremental encoder［J］.Journal of Electronic Measurement and Instrument,2012,26(11):993-998.(杜颖财,王希军,王树洁,等.增量式编码器自动检测系统［J］.电子测量与仪器学报,2012,26(11):993-998.)
［2］ZHOU D, YE Y. Modern fault diagnosis and fault-tolerant control［M］.Beijing: Tsinghua University Press,2000:3-16.(周东华,叶银忠.现代故障诊断与容错控制［M］.北京:清华大学出版社,2000:3-16.)
［3］ZHANG Y, JIANG J. Bibliographical review on reconfigurable fault-tolerant control systems ［J］.Annual Reviews in Control, 2008, 32(2):229-252.
［4］XU Y, JIANG B, GAO Z, et al. Fault tolerant control for near space vehicle: a survey and some new results ［J］. Journal of Systems Engineering and Electronics, 2011, 22(1):88-94.
［5］WU N E, THAVAMANI S, ZHANG Y, et al. Sensor fault masking of a ship propulsion system［J］.Control Engineering Practice, 2006, 11(14):1337-1345.
［6］SOURANDER M, VERMASVUORI M, SAUTER D, et al. Fault tolerant control for a dearomatisation process［J］. Journal of Process Control, 2009, 19(7): 1091-1102.
［7］JIANG J, YU X. Fault-tolerant control system: a comparative study between active and passive approaches［J］. Annual Reviews in Control, 2012, 36(1): 60-72.
［8］MAO H, LI W, FENG X. Review of active fault tolerant control for nonlinear system［J］.Transducer and Microsystems Technologies,2014,33(4):6-9,13.(毛海杰,李炜,冯小林.非线性系统主动容错控制综述［J］.传感器与微系统,2014,33(4):6-9,13.)
［9］ZHOU D, HU Y. Fault diagnosis techniques for dynamic systems［J］.Acta Automatica Sinica, 2009,35(6):748-758.(周东华,胡艳艳.动态系统的故障诊断技术［J］.自动化学报,2009, 35(6):748-758.)
［10］LI H, XIAO D. Survey on data driven fault diagnosis methods［J］.Control and Decision,2011,26(1): 1-9,16.(李晗,萧德云.基于数据驱动的故障诊断方法综述［J］.控制与决策,2011,26(1):1-9,16.)
［11］WANG H, CHAI T, DING J. Data driven fault diagnosis and fault tolerant control: some advances and possible new directions［J］. Acta Automatica Sinica,2009, 35(6):739-747.
［12］XIAO J, WANG H. An applicable diagnosis way on the fault of encoders in numeric control system［J］. Chinese Journal of Sensors and Actuators,2007,20(2):358-361.(肖金壮,王洪瑞.一种实用的数控系统中编码器故障诊断方法［J］.传感技术学报, 2007,20(2): 358- 361.)
［13］CHEN D, GUO X, YU C, et al. Research and realization of automatic monitoring and fault diagnosis system for coders［J］. Chinese Journal of Sensors and Actuators,2005, 18(3):617-619,622.(陈德国,郭晓松,于传强,等.编码器自动监测与故障诊断系统的研究与实现［J］.传感技术学报, 2005,18(3): 617-619,622.)
［14］CHEN X, LIU Y, LYU H. Wavelet processing based intelligent fault diagnosis of special photoelectrical encoders［J］. Journal of Huazhong University of Science and Technology: Natural Science Edition, 2010,38(4):79-82.(陈兴林,刘杨,吕恒毅.采用小波处理的空间光电编码器智能故障诊断［J］.华中科技大学学报:自然科学版,2010, 38(4):79-82.)
［15］LI G. Intelligent Control and its MATLAB implementation ［M］.Beijing: Electronic Industry Press, 2005:261-273. (李国勇.智能控制及其MATLAB实现［M］.北京:电子工业出版社,2005:261-273.)
［16］CAO G, LI M, WANG J, et al. Application of T-S neural network in prediction for anaerobic bioreactors ［J］.Chinese Journal of Environmental Engineering,2007,1(11):119-123.(曹刚,李明玉,王君,等. T-S模糊神经网络在厌氧反应器预测中的应用［J］.环境工程学报,2007,1(11):119-123. )
［17］SUN Y, YAN Y, ZHANG B, et al. Fuzzy neural network method based on the T-S model for the urban water demand forecasting and its application［J］.Journal of Safety and Environment,2013,13(2):136-139.(孙月峰,闫雅飞,张表志,等.基于T-S模型的模糊神经网络城市需水量预测方法研究［J］.安全与环境学报,2013,13(2):136-139.)
［18］KE Y, XIE B, WU Q. The vehicle fault diagnosis research based on T-S model fuzzy neural network［J］.Journal of Hangzhou Dianzi University, 2012,32(2):41-44.(柯喻寅,谢镔,吴卿.基于T-S模糊神经网络的汽车故障诊断系统的研究［J］.杭州电子科技大学学报,2012,32(2):41-44.)
［19］HE Y, ZHU K, GUO H, et al. Determining structure and parameters of fuzzy neural network［J］. Application Research of Computers,2007,24(3):247-249,252.(贺勇,诸克军,郭海湘,等.一种模糊神经网络的结构和参数的确定方法［J］.计算机应用研究,2007,24(3): 247-249,252.)
［20］LI W, LI Y. Application of the optimized M-SPRT method in pipeline leakage detection［J］.Natural Gas Industry, 2009, 29(4):93-95.(李炜,李阳.优化M-SPRT法在管道泄漏检测中的应用［J］.天然气工业,2009,29(4):93-95.)
［21］WEN X, ZHANG H, ZHOU L. Fault diagnosis and fault tolerant control for control systems［M］.Beijing: China Machine Press, 1998:64-69.(闻新,张洪钺,周露.控制系统的故障诊断和容错控制［M］.北京:机械工业出版社,1998:64-69.)
［22］CHEN B. Automatic control system for electric drive［M］.Beijing: China Machine Press, 2007:255-261. (陈伯时.电力拖动自动控制系统［M］.北京:机械工业出版社,2007:255-261.)